Dell Latitude D630c Service Manual

Dell™Latitude™D630ServiceManual Notes, Notices, and Cautions Information in this document is subject to change without notice. ©2007DellInc.A

   1. Align the pin-1 corner of the processor so that it points to the triangle on the system board, and insert the processor into the ZIF socket.

Back to Contents Page  Display Assembly Dell™Latitude™D630ServiceManual Removing the Display Assembly Removing the Display Bezel Removi

9. Turn the computer upside down with the back of the computer facing you.  10. From the back of the computer, remove the two M2.5 x 8-mm screws.

 4. Remove the six M2.5 x 5-mm shoulder screws from the front of the bezel.  5. Starting from the inside edges of the bezel, use your fingers to

  5. Lift the display panel a few inches from the top cover.  6. Draw the display cable pull-tab away from the top cover to release the display

 7. Squeeze the flex-cable release levers at either side of the top flex-cable connector to release the connector. Removing the Display Hinges

Back to Contents Page  Fan Dell™Latitude™D630ServiceManual    1. Follow the instructions in Before You Begin.  2. Remove the system boa

Back to Contents Page  Hard Drive Dell™Latitude™D630ServiceManual    To replace the hard drive in the hard drive bay:  1. Follow the proce

Back to Contents Page  Hinge Cover Dell™Latitude™D630ServiceManual    1. Follow the procedures in Before You Begin.  2. Open the displa

Back to Contents Page  Keyboard Dell™Latitude™D630ServiceManual Removing the Keyboard Replacing the Keyboard Removing the Keyboard  

Back to Contents Page  Before You Begin Dell™Latitude™D630ServiceManual Recommended Tools Turning Off Your Computer Before Working Insi

 1. Connect the keyboard connector to the system board.  2. Fold the pull-tab down and secure it and the keyboard cable underneath the locking ar

Back to Contents Page  Memory Dell™Latitude™D630ServiceManual DIMM A DIMM B   Your computer has two user-accessible SODIMM sockets, on

 5. Ground yourself and install the new memory module: a. Align the notch in the module edge connector with the tab in the connector slot. b. S

 4. Ground yourself and install the new memory module: a. Align the notch in the module edge connector with the tab in the connector slot. b.

Back to Contents Page  Communications Cards Dell™Latitude™D630ServiceManual Wireless Local Area Network (WLAN) Card Mobile Broadband Netwo

 5. To install a WLAN card: a. Move any antenna cables out of the way to make space for the WLAN card. b. Insert the WLAN card into the syste

 1. Follow the procedures in Before You Begin.  2. Remove the hinge cover (see Hinge Cover).  3. Remove the keyboard (see Removing the Keyboa

b. Insert the card into the system board connector at a 45-degree angle, and press the card into the metal securing tabs until you feel a click.

Back to Contents Page  Modem Dell™Latitude™D630ServiceManual    1. Follow the instructions in Before You Begin.  2. Remove any installe

Back to Contents Page  Media Bay Devices Dell™Latitude™D630ServiceManual  1. If present, remove the device locking screw from the bottom of t

 1. Ensure that the work surface is flat and clean to prevent the computer cover from being scratched.  2. Save and close any open files, exit any

Back to Contents Page  Palm Rest Dell™Latitude™D630ServiceManual    1. Follow the instructions in Before You Begin.  2. Remove any inst

 11. Turn the computer top-side up and remove the palm rest. a. Starting at the back center of the palm rest, use your fingers to separate the pal

Back to Contents Page  Using Cards Dell™Latitude™D630ServiceManual Card Types Removing a PC Card or Blank Installing a PC Card or an Ex

Press the release latch and remove the card or blank. For some release latches, you must press the latch twice: once to pop the latch out, and then a

Removing a Smart Card  Grasp the smart card by the edge with your fingers, and then pull the card straight out of the computer. Installing a

the slot. If you encounter too much resistance, do not force the card. Check the card orientation and try again. Back to Contents Page  1 smart c

Back to Contents Page  Speaker Dell™Latitude™D630ServiceManual    1. Follow the instructions in Before You Begin.  2. Remove any instal

Back to Contents Page  System Board Dell™Latitude™D630ServiceManual Removing the System Board Installing the System Board Removing the

 17. Remove the four 5-mm hex screws on the back of the computer.  18. Lift the system board out and away from the base. Installing the Sys

Back to Contents Page  Processor Thermal-Cooling Assembly Dell™Latitude™D630ServiceManual Removing the Processor Thermal-Cooling Assembly 

Back to Contents Page  Flashing the BIOS Dell™Latitude™D630ServiceManual Flashing the BIOS From a CD Flashing the BIOS From the Hard Drive

 1. Peel the backing off the thermal-cooling pad and adhere the pad to the portion of the thermal-cooling assembly that covers the processor.  2.

Back to Contents Page  Internal Card With Bluetooth®Wireless Technology Dell™Latitude™D630ServiceManual   If you ordered an internal card w

 6. Lift the card from the compartment, ensuring that you do not pull on the card cable with excessive force.  7. Disconnect the card from the ca

Back to Contents Page  PC Card Reader Dell™Latitude™D630ServiceManual    1. Follow the instructions in Before You Begin.  2. Remove any

Back to Contents Page  Coin-Cell Battery Dell™Latitude™D630ServiceManual    1. Follow the procedures in Before You Begin.  2. Remove th

Back to Contents Page  Processor Dell™Latitude™D630ServiceManual Removing the Processor Installing the Processor Removing the Processor